We provide whole set custom-made grain/bean cleaning plant solution. According to raw material condition/
cleaning requirement/budget, our experienced engineer will design appropriate Grain Cleaning Plant for customer.
We built grain cleaning plants over the 5 continents. Cleaning
material includes quinoa, sesame, wheat, maize, paddy, chickpea, red kidney
beans, etc. From small chia seeds to big pulses, we can offer you the cleaning
solutions. Capacity ranges from 3 ton per hour to 10 ton per hour. Our engineer
make reasonable plant layout in your workshop. No matter one-floor plant design
consisting 3 or 4 machines or two-floor plant design including machines more
than 10 sets. On-site plant installation and plant operation training are
available. You do not need worry about plant running and after-sales service.
One set grain cleaning plant normally including the flowing single seed
cleaning equipment: seed cleaner & grader, Gravity Separator , destoner, Indented Cylinder , color sorter, elevator, conveyor, Bagging Scale . Besides
this, the outdoor dust cleaning system, power control panel, underground hopper
is also the main features of the grain bean cleaning plant. Combining of different
cleaning purpose machines, the Grain Seed Cleaning Plant can reach cleaning
rate of 98%.
10 tons per hour barley plant in Australia
It is one simple 10 tons barley cleaning plant we built in Australia.
The main machines have barley deawner, Fine Seed Cleaner , gravity separator, bagging
scale system.
Main machine functions introduction:
Barley deawner: remove the husk/ shell coated on barley seeds.
Fine seed cleaner: remove the dust, light impurity as husk, straw,
big impurity and small impurity.
Gravity separator: remove the immature, eaten, sicken, shrink seeds.
Bagging Scale System: weighing and packing seeds to bags.
8 tons/hour kidney bean and 6 tons/hour Sesame Seed Cleaning Plant in
Ethiopia
Following is one two-floor Seed Cleaning Plant
reference. This grain cleaning plant is used to clean sesame, chickpea,
soybean, red kidney beans. One seed cleaning plants can be used to clean different
kinds of seeds. Only needing is to
change suitable sieves/ sieve bed for different seeds. This plant cleaning kidney
beans capacity is 8 tons per hour, and 6 tons per hour when clean sesame.
Grain And Bean Cleaning Plants,Sesame Seed Cleaning Plant,Bean Cleaning Plants,Grain Bean Seed Cleaning Plants SHIJIAZHUANG SYNMEC INTERNATIONAL TRADING LIMITED , https://www.seedgraincleaner.com
First, soak. The corn is soaked in warm water at 40°C for more than 24 hours until it fully absorbs water and expands. Judgment method: Corn kernels are cut longitudinally and no white powder can be found at the center.
Second, beating, filtering. The slurry was beaten with warm water below 50°C, the ratio of feed to water was 1:5, and then filtered through a 200 mesh filter cloth. The slurry was ready for use.
Third, liquefaction. The liquefaction enzyme was added to the corn juice, the pH was adjusted to 6 with citric acid, heated to about 95°C, and incubated for 1 hour.
Fourth, deployment. Fresh milk and corn juice were mixed at a ratio of 1:1, stabilizers, 6% sucrose, and a small amount of corn flavor and ethyl maltol were sequentially added and mixed thoroughly.
Fifth, homogenization. The uniform pressure is 40 MPa.
6, sterilization, cooling, inoculation. The slurry was incubated at a temperature of 95°C for 20 minutes, cooled to 42°C, and inoculated with 2.5% of the yeast extract.
Seven, training, after maturity. Finally, the corn milk was cultured at a temperature of 42°C for 3.5 hours, and then refrigerated at a temperature of 4°C for 24 hours to be a finished product.
Corn yoghurt is yogurt made by mixing corn with milk and fermenting it. It not only has a fresh corn flavor, it further improves the nutritional value of corn and milk, but also improves the economic benefits of corn. The production method of corn yoghurt is described as follows: